Colloidal-chemical mechanism of Zn(OH)₂–ZnO layer formation at the glass– ammonia solution– Zn(II) interface

Thermodynamic and experimental studies of Zn(OH)₂/ZnO particle formation conditions in the model of closed system Zn²⁺–NH_3,aq–NH_3,gas–H⁺–OH^––H2O–N_2,gas (1), which often occurs in the process of synthesis of zinc oxide nanoparticles and films by chemical bath deposition (CBD) methods, were carried out. It was shown that the driving force for the formation and growth of Zn(OH)₂/ZnO particles in the initially homo geneous system (1) at 25 C is the difference in the chemical potential of particles at the initial temperature (unsaturated system) and the synthesis temperature (supersaturated system). Using vibrational spectroscopy, X-ray phase and chemical analysis, diffuse light scattering and electrophoresis methods, it was found that the phase transformation of Zn(OH)₂ into ZnO takes place in the region of 85– 90 C. The colloid-chemical trans formation of Zn(NH₃)²⁺₄ ionic particles into colloidal polycrystals of Zn(OH)₂/ZnO composition was established for the first time to be a staged process. The first stage of the process in the solution volume is localized at the gas nanobubble-solution interface as a result of rapid formation, growth and removal of gas nanobubbles from the solution. The interaction of positively charged Zn(OH)₂ nanoparticles with the surface of larger negatively charged gas nanobubbles creates colloidal aggregates “bubble surface film of hydroxide nanoparticles”. Their adhesion forms an openwork foam-like structure of the colloid in the solution and in the film on the interfaces at the first stage of synthesis. After degassing of the electrolyte solution, the second stage develops, consisting of the nucleation and ionic-molecular growth of Zn(OH)₂/ZnO particles from the supersaturated solution, their distribution between the solution and the electrolyte– reactor wall– air interfaces. The film growth at this stage is regulated by the difference in surface charges of the double electric layer of the interface and polycrystalline colloidal particles. In the solution and on the interface, columnar Zn(OH)₂/ZnO structures grow as volumetric stars with conical hexagonal spikes.

1. Mokrushin S.G. Experimental study of laminar systems. J. of Physical Chemistry, 1934, 5 (8), P. 1082–1091.

2. Fabian I.E., Chandrakant D.L., Rajan J. Chemically Deposited Nanocrystalline Metal Oxide Thin Films: Synthesis, Characterizations, and Appli cations. Springer Cham, 2021, 926 p.

3. Guire M.R.D., Bauermann L.P., Parikh H., Bill J. Chemical Bath Deposition. In Chemical Solution Deposition of Functional Oxide Thin Films. Ed. Waser R., Kosec M., Payne D. Schneller T. Vienna, Springer, 2013.

4. Markov V.F., Maskaeva L.N., Kitaev G.A. Peculiarites of microstructure and properties of lead sulfide films deposited from halide-containing solutions. Inorganic materials, 2000, 36 (7), P. 792–795.

5. Kozhevnikova N.S., Markov V.F., Maskaeva L.N. Chemical deposition of metal sulfides from aqueous solutions: from thin films to colloidal particles. J. of Physical Chemistry, 2020, 94 (12), P. 1752–1766.

6. Fatehah M.O., Hamidi A.A., Serge S. Stability of ZnO nanoparticles in solution. Influence of pH, dissolution, aggregation and disaggregation effects. J. of Colloid Science and Biotechnology, 2014, 3 (1), P. 75–84.

7. Majid A., Bibi M. Cadmium based II-VI Semiconducting Nanomaterials Wet Chemical Synthesis Methods. Topics in Mining, Metallurgy and Materials Engineering, Springer, Cham, 2018, P. 43–101.

8. Guillemin S., Rapenne L., Roussel H., Sarigiannidou E., Br´emond G., Consonni V. Formation Mechanisms of ZnO Nanowires: The Crucial Role of Crystal Orientation and Polarity. J. of Physical Chemistry C, 2013, 117 (40), P. 20738–20745.

9. He J.H., Lao C.S., Chen L.J., Davidovic D., Wang Z.L. Large-scale Ni-doped ZnO nanowire arrays and electrical and optical properties. J. of the American Chemical Society, 2005, 127 (47), P. 16376–16377.

10. Comini E., Faglia G., Sberveglieri G., Pan Z.W., Wang Z.L. Stable and high-sensitive gas sensors based on semoconducting oxide nanobelts. Applied Physics Letters, 2002, 81 (10), P. 1869–1871.

11. HeJ.H., Hsin C.L., Liu J., Chen L.J., Wang Z.L. Piezoelectric gated diode of a single ZnO nanowire. Advanced Materials, 2007, 19 (6), P. 781–784.

12. Sun X., Li Q., Jiang J., Mao Y. Morphology-tunable synthesis of ZnO nanoforest and its photoelectrochemical performance. Nanoscale, 2014, 6 (15), P. 8769–8780.

13. P´ erez-Hern´andez R., Vel´ azquez Salazar J.J., Yacaman M.J. Low-Temperature Synthesis and Growth Mechanism of ZnO Nanorods on Crystalline Si Substrate. J. of Nano Research, 2011, 14, P. 69–82.

14. Wang M., Jiang L., Jung Kim E., Hahn S.H. Electronic structure and optical properties of Zn(OH)2: LDA+U calculations and intense yellow luminescence. RSC Advances, 2015, 5 (106), P. 87496–87503.

15. Alnoor H., Chey Ch.O., Pozina G., Liu X., Khranovskyy V., Willander M., Nur O. Effect of precursor solutions stirring on deep level defects concentration and spatial distribution in low temperature aqueous chemical synthesis of zinc oxide nanorods. AIP Advances, 2015, 5, 087180.

16. Baviskar P.K., Nikam P.R., Gargote S.S., Ennaoui A., Sankapal B.R. Controlled synthesis of ZnO nanostructures with assorted morphologies via simple solution chemistry. J. of Alloys and Compounds, 2013, 551, P. 233–242.

17. Znaidi L. Sol-gel-deposited ZnO thin films: A review. Materials Science and Engineering B, 2010, 174, P. 18–30.

18. Le Pivert M., Martin N., Leprince-Wang Y. Hydrothermally grown ZnO nanostructures for water purification via photocatalysis. Crystals, 2022, 12 (3), 308.

19. Gonzalez-Chan I.J., Moguel Z.P., Oliva A.I. Deposition of ZnO thin films by chemical bath technique: physicochemical conditions and character ization. ECS J. of Solid State Science and Technology, 2019, 8 (9), P. 536–544.

20. Kahraman S., C¸akmak H.M., C¸etinkaya S., C¸etinkara H.A., G¨ uder H.S. CBD grown ZnO nanostructures: effects of solution temperature. Int. J. of Materials Research, 2013, 104 (8), P. 798–804.

21. Trejo-Ramos A.I., Mart´ın-Varguez P.E., Gonzalez-Chan I.J., Oliva A.I. Algorithm to obtain the species distribution diagrams and solubility curves for depositing ZnS, ZnO, and Zn(OH)2 films in aqueous solution. Computational and Theoretical Chemistry, 2021, 1202, 113325.

22. Stefan M., Nistor S.V., Ghica D. ZnS and ZnO Semiconductor Nanoparticles Doped with Mn2+ Ions. Size Effects Investigated by EPR Spec troscopy. Springer Series in Materials Science, 2014, 205, P. 3–27.

23. Molefe F. V., Koao L. F., Dejene B. F., Swart H. C. Phase formation of hexagonal wurtzite ZnO through decomposition of Zn(OH)2 at various growth temperatures using CBD method. Optical Materials. 2015, 46, 292-298.

24. Polyakov E.V., Tzukanov R.R., Volkov I.V., Buldakova L.Yu., Baklanova I.V., Lipina O.A., Zhukov V.P., Kuznetsova Yu.V., Tutyunnik A.P., Max imova M.A. Synthesis and comparative photocatalytic activity of CuO layers on SiO2 substrates. Nanosystems: Physics, Chemistry, Mathematics, 2020, 11 (5), P. 601–607.

25. Polyakov E.V., Tsukanov R.R., Buldakova L.Yu., Kuznetsova Yu.V., Volkov I.V., Zhukov V.P., Maksimova M.A., Dmitriev A.V., Baklanova I.V., Lipina O.A., Tyutyunnik A.P. Chemical Bath Precipitation and Properties of-Ni(OH)2 Films Prepared in Aqueous Ammoniac Solutions. Russian J. of Inorganic Chemistry, 2022, 67 (6), P. 912–920.

26. Vasiliev V.P. Thermodynamic properties of electrolyte solutions. Vysshaya Shkola, 1982, 320 p.

27. Kotrly S., Suka L. Handbook on chemical equilibriq in analytical chemistry. Ellis Horwood Limi` oed, Chichester, 1985, 253 p.

28. Margulis M.A. Sonoluminescence. Uspekhi Fizicheskih Nauk, 2000, 170 (3), P. 263–287.

29. Lutz H.D, Jung C., M¨ ortel R., Jacobs H., Stahl R. Hydrogen bonding in solid hydroxides with strongly polarising metal ions, b-Be(OH)2 and o-Zn(OH)2. Spectrochimica Acta Part A, 1998, 54, P. 893–901.

30. Kim K.M., Kim T.H., Kim H.M., Kim H.J., Gwak G.H., Peak S.M., Oh J.M. Colloidal behaviors of ZnO nanoparticles in various aqueous media. Toxicology and Environmental Health Sciences, 2012, 4 (2), P. 121–131.

31. Zhang X., Wang Q., Wu Zh., Tao D. An experimental study on size distribution and zeta potential of bulk cavitation nanobubbles. Int. J. of Minerals, Metallurgy and Materials, 2020, 27 (2), P. 152–161.

32. Li M., TongguL., Zhan X., MegaT.L., WangL.Cryo-EMVisualization of Nanobubbles in Aqueous Solutions. Langmuir, 2016, 32 (43), P. 11111 11115 .

33. Agarwal A., Ng W.J., Liu Y. Principle and applications of microbubble and nanobubble technology for water treatment. Chemosphere, 2011, 84 (9), P. 1175–1180.

34. Alheshibri M., Baroot A.A., Shui L., Zhang M. Nanobubbles and nanoparticles. Current Opinion in Colloid & Interface Science, 2021, 55 (43), 101470.

35. Bui T.T., Nguyen D.C., Han M. Average size and zeta potential of nanobubbles in different reagent solutions. J. of Nanoparticle Research, 2019, 21 (8), P. 1–11.

36. Pawar S.M., Gurav K.V., Shin S.W., Choi D.S., Kim I.K., Lokhande C.D., Rhee J.I., Kim J.H. Effect of bath temperature on the properties of nanocrystalline ZnO thin films. J. of Nanoscience and Nanotechnology, 2010, 10 (5), P. 3412–3415.